Safe Operating PracticesSome of the following safety instructions are from ANSI Standard B-71.4-1999 while others are specific to the Hustler Mid Moun
600876_0706▲Do not mow on wet grass. Reduced traction could cause sliding.▲Do not try to stabilize the machine by putting your foot on theground.▲If
IMPORTANT: When access is required under the seat platform andthe seat is equipped with the optional arm rests, make certain to placethe control arms
600876_0706J. Electronic hour meter (Fig. 3-5) — registers 1/10 hour incrementsup to 9,999.9 total hours. Connected to the ignition switch, themeter
1. Before starting tractor each day, perform daily pre-operationchecking. (See Safety start interlock system section)2. Make sure the control levers
600876_0706Driving the tractorDANGER: Never make sudden stops or reverse direction,especially when maneuvering on a slope. The steering isdesigned fo
WARNING: If you lose steering control while operatingthe machine, place the steering control levers in the parkbrake position immediately. Inspect th
600876_0706Mower deck operationDANGER: Never attempt to make any adjustments to themower deck while the engine is running or with the deckdrive clutch
When the chains are placed in the top hole of the deck chain bracketsand the height adjusting stop is placed in the front height adjusting bar hole,wi
600876_0706Figure 3-16FrontmountlegsRearmountlegs18
This manual applies to the following Hustler equipment lines:Hustler Z/Super ZSuper Z DieselHustler ATZHustler Mini Z 44/52Super Mini Z 44/52To the ne
MAINTENANCE & ADJUSTMENTSSafe Servicing PracticesThis product is capable of amputating hands and feet and throwingobjects. Always follow all safe
600876_0706Hustler Z/Super Z/Hustler ATZ/Hustler Mini Z/Super MiniZThe hydraulic reservoir is located in front of the engine and under theoperator’s p
standard oil filter wrench is used to change filter, threads are right handed.Use a Hustler approved filter element only.IMPORTANT: Prefill the filte
600876_0706and repair the source of ingested dirt.6. Never operate a machine without an air filter installed.Super Z liquid cooled/Super Z DieselThe S
BeltsInspect belts frequently for wear and serviceability. Replace a belt thatshows signs of severe cuts, tears, separation, weather checking andcrac
600876_0706Control lever adjustmentThe control levers can be adjusted for operator comfort. By looseningthe cap screws that attaches the upper contro
WEEKLY MONTHLY ANNUALLY ORSERVICE AT OR 50 OR 100 500INTERVALS INDICATED HOURS HOURS HOURSVerify safety start interlock system DailyVisually inspect
600876_0706WEEKLY MONTHLY ANNUALLY ORSERVICE AT OR 50 OR 100 500INTERVALS INDICATED HOURS HOURS HOURSCheck coolant level Every 8 hoursVerify safety st
Hustler Mini Z/Super Mini ZMaintenance Locator Chart1A. Engine Oil Fill & Dipstick(Kawasaki & Honda)1B. Engine Oil Fill & Dipstick(Kohler)
600876_0706Hustler Z/Super ZMaintenance Locator Chart1a. Engine Oil Fill & Dipstick (Kawasaki & Honda)1b. Engine Oil Fill & Dipstick (Kohl
600876_0706HUSTLER Z/SUPER Z/HUSTLER ATZ/SUPER Z DIESEL/HUSTLER MINI Z/SUPER MINI ZTWO YEAR LIMITED WARRANTY FOR TRACTORS AND DECKS(THREE YEAR LIMITED
Hustler Z/Super ZMaintenance Locator Chart1. Deck Idler Zerk (1)2. Deck Pusher Arm Zerks (2)3. Deck Belt4. Spindle Housing Zerk (3)5. Blades5522144432
600876_0706Hustler Z/ Super Z/ ATZMaintenance Locator Chart1. Deck Pusher Arm Zerks (2)2. Deck Belt3. Spindle Housing Zerk (3)4. Blades441133321412334
Hustler ATZ MaintenanceLocator Chart6122431316111311514761413132111510151619Figure 4-171. Engine Oil Fill & Dipstick2. Fuel Filter3. Engine Air Cl
600876_0706Figure 4-183881061113556127101010111214151162941. Engine Oil Fill 2. Fuel Filter3. Engine Air Cleaner4. Engine Oil Drain Plug5. Battery6. F
88221166654731. Deck Idler Zerk (1)2. Deck Pusher Arm Zerks (2)3. Hydraulic Oil Filter4. Pump Idler Zerk (1)5. Deck Belt6. Spindle Housing Zerk (3)7.
600876_0706Hustler Z/Super Z/Super Z Diesel/Hustler ATZ/Hustler Mini Z/Super Mini ZTROUBLESHOOTINGThe majority of operating problems that occur with a
This section contains sources of additional literatureconcerning your tractor. Literature should be ordered fromyour Hustler dealer or direct from in
600876_0706INDEXPAGEAnti-scalp wheels...17BAC-VAC mounting ...
state.LIMITATION OF REMEDIESIn no case shall Hustler Turf Equipment, be liable for any special,incidental, or consequential damages based upon breach
600876_0706This safety alert symbol is used to call attention to a message intended toprovide a reasonable degree of PERSONAL SAFETY for operators and
Avoid skin contact with battery acid.Always wear eye protection whenchecking the battery, acid can causeserious injury to skin and eyes. If contactoc
600876_07066
C (5o)D (10o)E (15o)Line ALine BSlope Guide LinesF (25o) - Hustler ATZ only600876_07061. Hold this sheet of paper in front of you. Make sure that l
600876_07068
Comments to this Manuals